Posts Tagged With: diy wool hunting shirt

100% Wool Army Blanket = Awesome Hunting Shirt

by Todd Walker

I love wool! Here’s why:

  • Wool fiber absorbs up to 36% of its weight and gradually releases moisture through evaporation.
  • Wool has natural antibacterial properties that allow you wear it multiply days without stinking up camp. Not so with synthetics.
  • Wool wicks moisture, not as well as synthetics, but better than cotton.
  • Wool releases small amounts of heat as it absorbs moisture.
  • Wool contains thousands of natural air-trapping pockets for breathable insulation.

Years ago I saw Dave Canterbury make a hunting shirt from a wool blanket. Naturally, I had to make one myself. I ordered two 100% wool army blankets from Cheaper than Dirt for around 20 bucks each. Good luck finding them at that price now.

100% Wool Blanket = Awesome Hunting Shirt

My original hunting shirt

I wore this while working on this fat lighter’d post. A few of our readers requested a tutorial on making one themselves. Hope you enjoy.

Material and Tools

  • A 100% wool blanket
  • Scissors
  • Tread and needle
  • Measuring device
  • Tailor’s chalk

Step 1: Lay out for torso

There’s two ways to get the proper width of your shirt. Place arms by your side and measure around your chest and arms at the widest part of your shoulders. If your measurement is 50 inches, divide that in half and add 4 inches (50/2 + 4 = 29).

100% Wool Blanket = Awesome Hunting Shirt

Measure with layers you’d normally wear

Or you can fold the blanket in half with about a 12 inch offset on the bottom, place it on the floor and lay your body on top of the blanket. Mark the width of your shoulders and give yourself a few of inches over your shoulder length to make your cut. This width is dependent upon how roomy you want your shirt.

Step 2: First cut

With your blanket folded length-wise, the front of your shirt should be about one foot shorter than the back. A longer panel on the back covers your bottom when you sit.

100% Wool Blanket = Awesome Hunting Shirt

The front panel of this new shirt is just over 36 inches long

100% Wool Blanket = Awesome Hunting Shirt

Cut the width mark the full length of your folded blanket

Mark and cut the width of your shirt.

Step 3: Cut the neck hole

Make a center mark along the ridge of the fold. Now measure out 4 to 5 inches on both sides of the center and cut a slit in the ridge. In the center of this neck hole slit, cut another 6 inch slit perpendicular to the first slit on the front panel.

100% Wool Blanket = Awesome Hunting Shirt

It now looks like a poncho

Try it on. Your head should go through easily. Tweak as much as needed.

Step 4: Cut the sleeves

Measure around the top of your shoulder to the middle of your ribcage. Take half of that measurement for the width of your sleeves where it will connect to the torso portion.

100% Wool Blanket = Awesome Hunting Shirt

The factory hem is on the hand end of the sleeve

My sleeve dimensions:

  • 14 inches wide at the body – ample room for arms to move about
  • 6 1/2 inches at the hand end
  • 24 inches long from should to hand end – this length give me a generous cuff on the sleeve which can be rolled over my hands when needed

Double the leftover material from your torso, measure and mark the width, and cut two sleeves.

Step 5: Sew it together

If you’re good with a sewing machine on wool, go for it. I’m not. I hand stitched my first wool shirt. I used a blanket stitch on the edges and all seams. Here’s the blanket stitch tutorial I used. 

Turn the shirt inside out if you don’t want seams exposed. Once sewn, turn it right side out. Be sure to double or triple stitch stress points on your shirt.

Note: When stitching the sides below the sleeve, I stopped at my waist line. This allows me to reach my pant pockets, sidearm, and knife without lifting my shirt.

Stitch some short pieces of paracord to the v-cut in the neck for closure. I also added this same feature the sides below my waist to close the slit if need be. (Melt the ends of the cord to prevent unraveling)

I wanted to make this new shirt with a hood but didn’t like the design. Any suggestions are more than welcome. If you make one for yourself, we’d like to hear how it turned out.

Keep Doing the Stuff,

Todd

P.S. – You can also keep up with the Stuff we’re Doing on TwitterPinterestGoogle +, and our Facebook page. Trade theory for action and join us in the Doing the Stuff Network on these social media sites: PinterestGoogle +, and Facebook.

P.P.S ~ If you find value in our blog, DRG and I would appreciate your vote on the Top Prepper Sites! You can vote daily by clicking here or on the image below. Check out all the other value-adding Prepper Sites while you’re there…

Thanks for sharing the stuff!

Copyright Information: Content on this site (unless the work of a third-party) may be shared freely in digital form, in part or whole, for non-commercial use with a link back to this site crediting the author. If you are interested a third-party article, please contact the author directly for republishing information.

Categories: Bushcraft, DIY Preparedness Projects, Doing the Stuff, Self-reliance | Tags: , , | 17 Comments

Blog at WordPress.com.

%d bloggers like this: